Storm Cleanup? Think Safety Before You Use Chainsaw

Cornelis De Hoop, Benedict, Linda F.

Professional loggers wear personal protective equipment, even in hot weather. Experts with the LSU AgCenter say homeowners using chainsaws should do the same.

News Release Distributed 09/04/08 

Hurricane Gustav put a lot of limbs and whole trees on the ground in various areas of the state, and many people already are working on cleanup efforts.

An LSU AgCenter forest safety specialist says safety should be a major consideration during those efforts – particularly when it comes to use of a chainsaw.

It’s been said that more people are injured during storm cleanup than by a storm itself, according to Dr. Niels de Hoop, associate professor in the LSU AgCenter’s Louisiana Forest Products Development Center.

"Professional loggers have made great strides in chainsaw safety, but homeowner chainsaw users tend to violate nearly every safety rule in the book," de Hoop says. "Chainsaw accident rates are high."

De Hoop says chainsaw cuts are particularly dangerous because they can easily cause severe bleeding.

"Unlike the clean cut of a knife, chainsaws remove body tissue as they cut," he says. "This makes injury repair and recovery difficult."

He also warns that chainsaws may be loud enough to cause permanent hearing loss. And overhead hazards may lurk if you’re felling trees.

Chainsaw safety starts when you purchase the saw.

"Don’t just purchase a saw by itself," de Hoop says. "Purchase personal protective equipment (PPE in safety jargon) along with it."

Available from most dealers who sell chainsaws, this safety equipment doesn’t prevent accidents, but it may keep an accident from being as bad as it could have been, the forest safety specialist says.

The U.S. Occupational Safety and Health Administration requires the following personal protection equipment to be used by any employee who uses a chainsaw: hard hat (if an overhead hazard exists, such as when cutting a tree), eye protection, hearing protection, gloves, leg protection and foot protection.

"Homeowners using chainsaws should do the same," de Hoop says.

If there are trees and treetops overhead, the need for a hardhat is obvious, de Hoop says. In cleanup cases, electric lines commonly are nearby, so one should use a plastic hardhat rather than a metal one.

Since the most commonly injured body part is a leg, the next most important PPE is leg protection, commonly in the form of saw chaps. These chaps have multiple layers of Kevlar or ballistic nylon – similar to bullet-proof vests. When it’s drawn into the saw, the chain stops running.

"I personally know two occasional chainsaw users who prevented a severe injury to the leg because they were wearing saw chaps," de Hoop says. "The cost of these chaps – about $70 –is cheaper than a doctor’s visit. Many loggers will tell you that saw chaps are hot in summer but still worth wearing because of the protection."

De Hoop says foot protection is technically more difficult. Chainsaw-protective boots cost anywhere between $150 to $400 per pair.

"Despite their cost, they’re not as effective as leg protection because of natural design limitations," he says.

One solution for the occasional user is a protective overshoe called the SawJammer, although de Hoop says the most economical solution is ballistic nylon socks. But the socks require a boot several sizes larger.

"Stout rubber boots that have the saw protection molded in are the most effective because the saw teeth have difficulty biting into rubber," de Hoop says. "By contrast, chainsaws cut very easily into heavy leather."

Hearing protection also is very important. Operating a properly functioning chainsaw for more than two hours without hearing protection will begin permanent hearing loss, experts say. If the muffler is removed, permanent hearing loss will start in 15 minutes.

"Hearing protection comes in two forms – ear plugs and ear muffs," de Hoop says. "Muffs are slightly more effective than plugs and do not aggravate earwax buildup. Either kind works well with normal chainsaw use."

Since chainsaws spray small wood chips in all directions, de Hoop says some kind of eye protection is critical. Common safety glasses, goggles and face screens are effective. In hot weather, perspiration can cause fogging of goggles and face shields.

"Luckily, screens or glasses that wrap around to the side of the eye are effective," he says.

"For about $45, you can purchase a chainsaw helmet system," de Hoop says. "This is a hardhat with earmuffs and face screen attached. The muffs and screen can be flipped out of the way easily when not needed."

While this is a convenient package for occasional users (and professionals), de Hoop says a major drawback is that the muffs are hot in Louisiana’s summers.

"A popular and effective alternative in hot weather is an ordinary hardhat, ear plugs and wrap-around sunglasses," he says.

Other types of PPE for chainsaw users include gloves and upper body protection (vests). Gloves are available with a ballistic nylon lining on the back

Being properly outfitted for chainsaw use is only the beginning of chainsaw safety, de Hoop says. Proper training, fueling, starting, cutting techniques and maintenance are all important, too.

"All chainsaw users should obtain and wear proper PPE to reduce the chance of serious injury," de Hoop says. "Obtain them before cleaning up storm-damaged trees."

He also suggests they also make excellent holiday gifts for the firewood season.


Contact: Niels de Hoop at (225) 578-4242 or

9/3/2005 3:52:56 AM
Rate This Article:

Have a question or comment about the information on this page?

Innovate . Educate . Improve Lives

The LSU AgCenter and the LSU College of Agriculture